Move to open sky for Skylon spaceplane

 
Farnborough David Willetts (L) discusses Skylon with Alan Bond (C) and Tim Hayter (R)

The UK government says it is working to put in place the regulations that would license the operation of spaceplanes.

Current arrangements prohibit these vehicles from using European airspace, according to ministers, and they want the certification system updated.

The move is aimed at smoothing the path to market of novel launch systems such as the Skylon concept being developed by Reaction Engines Limited (REL).

The Oxfordshire company's robotic vehicle is part aeroplane, part rocket.

It would take off horizontally from a runway and go straight to orbit without the need for the multiple propellant stages seen in today's throw-away launchers. Skylon would then land back on Earth at the same runway.

Reaction Engines claim the system could dramatically lower the cost of putting satellites in space.

But the vehicle's unique capabilities mean it does not fit into any current regulatory regime, and unless that is changed its entry into service will be blocked.

Speaking at the Farnborough International Airshow, Science Minister David Willetts said he intended to address this issue with both the UK Department of Transport and the European Commission.

"At the moment, there is just a complete gap - there is no European regulatory regime for reusable space vehicles, and we need one," he told BBC News.

Mr Willetts made his comments when he visited the REL stand here at Farnborough.

Skylon concept (Reaction Engines) Skylon would operate from a runway

The company is showcasing its revolutionary Sabre engine technology, which is two-thirds of the way through an important test campaign at its Culham base.

Sabre would burn hydrogen and oxygen to provide thrust - but in the lower atmosphere this oxygen would be taken from the atmosphere.

At high speeds, the engine is required to cope with 1,000-degree gases entering its intake. These have to be cooled prior to being compressed and burnt with the hydrogen.

REL's solution is a module containing arrays of extremely fine piping that can extract the heat and plunge the intake gases to minus 140C in just 1/100th of a second.

Ordinarily, the moisture in the air would be expected to freeze out rapidly, covering the pre-cooler's pipes in a blanket of frost and dislocating their operation.

But the company's engineers have also devised a means to stop this happening, permitting Sabre to run in jet mode for as long as is needed before making the transition to full rocket mode to take Skylon into orbit.

It is the critical "pre-cooler" technology with its innovative helium cooling loop that REL is validating currently on an experimental rig at Culham.

Sabre engine: How the test campaign is conducted
Illustation of how the skylon engine works Groundbreaking pre-cooler
  • 1. Pre-cooler

    During flight air enters the pre-cooler. In 1/100th of a second a network of fine piping inside the pre-cooler drops the air's temperature by well over 100C. Very cold helium in the piping makes this possible.
  • 2. Jet engine

    Oxygen chilled in the pre-cooler by the helium is compressed and burnt with fuel to provide thrust. In the test run, a jet engine is used to draw air into the pre-cooler, so the technology can be demonstrated.
  • 3. The silencer

    The helium must be kept chilled. So, it is pumped through a nitrogen boiler. For the test, water is used to dampen the noise from the exhaust gases. Clouds of steam are produced as the water is vapourised.

The company's message here at Farnborough is that the pre-cooler is performing as expected - air flows through the module in a stable and uniform way, free from any vibration.

The pre-cooler has also been run at sub-zero temperatures where frost would be expected to form were it not for the anti-frosting mechanism, although the REL engineers have yet to take the system all the way down to below minus 140C . That will be done in the coming months.

"We've been down to sub-zero temperatures with completely stable operation; we've had steady-state operation for over six minutes," explained Alan Bond, the driving force behind the Skylon concept.

"We've now stopped the programme for the time being, to upgrade our test facilities in order to go down to much lower temperatures. We expect to complete that testing by the end of the year."

The Skylon/Sabre programme is being assessed by the European Space Agency (Esa). Its propulsion experts have been conducting a technical audit at the request of the UK Space Agency, to provide an independent view of the pre-cooler's capabilities and performance.

And the progress is being followed at the highest level within Esa.

"I am a rocket engineer and I have looked at the Skylon project," the Paris-based agency's director-general, Jean-Jacques Dordain, told BBC News.

"We are discussing with Reaction Engines how we can continue to work with them to get some more insights on their project… some more technical studies."

B9 test stand The pre-cooler demonstration is being conducted at REL's HQ in Oxfordshire

So far, only 15% of the funding to run the project has come from public sources; the rest has been private finance.

The company has now appointed a new chief executive, Tim Hayter.

One of his roles is to find the £250m needed to take Skylon/Sabre into its final design phase.

"We need to find investors or strategic partners with the vision and drive to see the long-term on this," he said.

"It's not going to be a quick turn-around [investment], but this is a disruptive technology that could turn launch vehicles on their head and we need people who can see that."

The prospect of some further UK government funding is not out of the question, either.

"We see this as predominantly a commercial project and it has already successfully raised money in the city," said Mr Willetts.

"We are considering whether there is any way we can provide them with further public assistance. No decision has been taken on that yet, and of course the overall budget position for the government is very tight."

Sabre Engine (Reaction Engines) An impression of the Sabre engine with a series of pre-cooler modules
 
Jonathan Amos, Science correspondent Article written by Jonathan Amos Jonathan Amos Science correspondent

More on This Story

Related Stories

The BBC is not responsible for the content of external Internet sites

Comments

This entry is now closed for comments

Jump to comments pagination
 
  • rate this
    -25

    Comment number 21.

    I am concerned about space flights for people; we have enough environmental damage from normal air flights (and likely vastly to increase when all Chinese citizens have the money to travel) and this is just another step towards ruining the planet.
    Those who are obsessed by travel will vote this down, but that just proves I am correct.

  • rate this
    -11

    Comment number 25.

    When are we going to get our priorities right? We waste in excess of £302,000,000 per year keeping a German queen and a Greek prince consort in the lap of luxury while our poor get poorer and our industries are starved of funds. Sad, deluded brainwashed Britain!

  • rate this
    -10

    Comment number 46.

    The enormously wealthy funded the building of the railways and canal that enabled the country to create enormous wealth during the industrial revolution.

    This simply is not possible today with space exploration, our rich aren’t rich enough and our poor are not poor enough, luckily!

    Only state funding will provide the infrastructure to support space exploration.

  • rate this
    -9

    Comment number 60.

    Skylon: space 'aircraft' within 10 years? Cost £700M - "Skylon Spaceplane" can travel at more than 5 times speed of sound. Costing about £6.3M/FLIGHT, 270 foot-long craft can carry up to 24 passengers. UNPILOTED craft - 2 engines use hydrogen & oxygen to propel it 18 miles + into space. Apparently Russia is into this & ESA while I can only wonder WHY. Will this become new war-toy?

  • rate this
    -8

    Comment number 63.

    Focus right now: getting idea out of concept/testing & into production. First flying vehicles in 2016; first production standard vehicles will fly in 2018 & after a 2 year test program, SKYLONs will go into commercial service in 2020; that's 8 years away.
    So many people think this is great; they don't mind investing. Why? How will this vehicle serve average person?

 

Comments 5 of 97

 

Features

BBC © 2014 The BBC is not responsible for the content of external sites. Read more.

This page is best viewed in an up-to-date web browser with style sheets (CSS) enabled. While you will be able to view the content of this page in your current browser, you will not be able to get the full visual experience. Please consider upgrading your browser software or enabling style sheets (CSS) if you are able to do so.